simplebooklet thumbnail

This brochure discusses the Ez Polish System.

Not just tools
Not just a chemical
Not just a meter
IT'S A SYSTEM!
Less Costs
Less Time
Revolutionizing
the industry
info@fast-prep.com
info@fast-prep.com
info@fast-prep.com || 802-489-0828
EZ Green Cut
Safety Data Sheet
SECTION 1: Identification of the substance/mixture and of the company/understaking
Product name. : Ez Green Cut
Use of the substance/mixture : Diamond profiling solution for professionals
EZ Polish System
PO Box 710931
Santee, CA 92072
(844) 376-5474
Emergency number : 800-424-9300(Within USA) 703-527-3887(Outside USA)
SECTION 2: Hazards identification
GHS-US classification
Acute Toxicity-Oral: Category 5
Skin Corrosion/Irritation: Category 3
Serious Eye Damage/Eye Irritation Category 2B
GHS-US labelling
Hazard pictograms (GHS-US) :
GHS07
Signal word (GHS-US) : Warning
Hazard statements (GHS-US) : H315 - Causes skin irritation
H319 - Causes serious eye irritation
Precautionary statements (GHS-US) : P264 - Wash ... thoroughly after handling
P280 - Wear protective gloves/protective clothing/eye protection/face protection
P302+P352 - IF ON SKIN: Wash with plenty of soap and water
P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing
P321 - Specific treatment (see ... on this label)
P332+P313 - If skin irritation occurs: Get medical advice/attention
P337+P313 - If eye irritation persists: Get medical advice/attention
P362 - Take off contaminated clothing
No additional information available
No data available
SECTION 3: Composition/information on ingredients
No ingredients are hazardous according to OSHA criteria.
No components need to be disclosed according to the applicable regulations.
NOTE: The identity of this material is a trade secret (29 CFR 1910.1200(i)) and is available to any attending physician, paramedical personnel and/or
spill response personnel in the case of an emergency. There are no additional ingredients present which, within the current knowledge of the
manufacturer and in the concentrations applicable, classified as hazardous to the health or environment thus do not require reporting in this section.
Name
Product identifier
%
GHS-US classification
Proprietary Component 1
(CAS No) Trade Secret
Trade Secret
Not classified
Proprietary Component 2
(CAS No) Trade Secret
Trade Secret
Not classified
Proprietary Component 3
(CAS No) Trade Secret
Trade Secret
Not classified
SECTION 4: First aid measures
First-aid measures after inhalation : move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
04.03.14 EN (English) 1/4
2.4. Unknown acute toxicity (GHS US)
1.1. Product identifier
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.3. Details of the supplier of the safety data sheet
1.4. Emergency telephone number
2.1. Classification of the substance or mixture
2.2. Label elements
2.3. Other hazards
3.1. Substances
3.2. Mixture
4.1. Description of first aid measures
04.03.14
EN (English)
2/4
First-aid measures after skin contact : Remove any contaminated clothing first. Wash off with soap and plenty of water. If
irritation occurs consult a physician.
First-aid measures after eye contact : Immediately flush eyes with plenty of water for at least 15 minutes. If irritation persists get
medical attention.
First-aid measures after swallow : Never give anything by mouth to an unconscious person. Rinse mouth with water. If irritation
occurs consult a physician.
Symptoms/injuries after inhalation : None under normal use.
Symptoms/injuries after skin contact : Causes skin irritation
Symptoms/injuries after eye contact : Causes serious eye irritation.
Symptoms/injuries after ingestion : May be harmful if swallowed.
No additional information available
SECTION 5: Firefighting measures
Suitable extinguishing media : Water spray, dry chemical, foam, carbon dioxide.
Unsuitable extinguishing media : None.
Fire hazard : None known.
Explosion hazard : None known.
Protection during firefighting : Wear self-contained breathing apparatus for firefighting if nessary
SECTION 6: Accidental release measures
Use personal protective equipment. Avoid breathing any vapors or mist. Ensure adequate ventilation. Move personnel to safe areas.
Soak up with inert absorbent material and dispose of in accordance with local and state disposal regulations. Keep in suitable closed containers for
proper disposal.
No additional information available
SECTION 7: Handling and storage
Precautions for safe handling : Avoid contact with eyes, skin and clothing. Wash thoroughly after handling.
Storage conditions : Keep container tightly closed in a dry and well ventilated place. Open containers must be
carefully closed/resealed and kept upright to prevent leakage. Do not mix with strong oxidizing agent.
No additional information available
SECTION 8: Exposure controls/personal protection
Contains no substances with occupational exposure limit values.
8.2.1 Appropriate engineering controls : Handle in accordance with good industrial hygiene and safety practices. Personal protective
equipment may be worn for added safety in accordance with the below recommended equipment. Wash hands before all breaks and at the end of
the workday.
8.2.2 Skin protection : While skin protection is not required, where protection from nuisance levels are desired, Gloves
must be inspected prior to use. Use proper glove removal technique. Dispose of contaminated gloves after
use in accordance with applicable laws and good laboratory practices. Wash and dry hands.
8.2.3 Eye protection : While eye protection is not required, where protection from nuisance levels are desired, use
equipment for eye
protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU).
8.2.4 Skin and body protection : Wear suitable working clothes.
8.2.5 Respiratory protection : While Respiratory protection is not required, where protection from nuisance levels are desired,
use type N95 (US) or type P1 (EN 143) dust masks. Use respirators and components tested and approved under appropriate government standards
such as NIOSH (US) or CEN (EU).
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed
5.1. Extinguishing media
5.2. Special hazards arising from the substance or mixture
5.3. Advice for firefighters
6.1. Personal precautions, protective equipment and emergency procedures
6.2. Methods and material for containment and cleaning up
6.3. Reference to other sections
7.1. Precautions for safe handling
7.2. Conditions for safe storage, including any incompatibilities
7.3. Specific end use(s)
8.1. Components with workplace control parameters
8.2. Exposure controls
04.03.14
EN (English)
3/4
8.2.6 Body Protection : While body protection is not required, where protection from nuisance levels are desired,
Choose body protection in relation to its type, to the concentration and to the specific work-place.
04.03.14
EN (English)
4/4
SECTION 9: Physical and chemical properties
Physical state
Odour
Odour threshold
pH
Relative evaporation rate (butylacetate=1)
Melting point
Freezing point
Boiling point
Flash point
Self ignition temperature
Decomposition temperature
Flammability (solid, gas)
Vapour pressure
Relative vapour density at 20 °C
Relative density
Solubility
Log Pow
Log Kow
Viscosity, kinematic
Viscosity, dynamic
Explosive properties
Oxidising properties
Explosive limits
: Liquid
: Mild soapy
: No data available
: No data available
: No data available
: No data available
: ≤ 26F
: 234F
: No data available
: No data available
: No data available
: No data available
: No data available
: No data available
: No data available
: in water
: No data available
: No data available
: No data available
: No data available
: No data available
: No data available
: No data available
No additional information available These physical properties are typical values for this product and not specifications.
SECTION 10: Stability and reactivity
10.1. Reactivity
No additional information available
10.2. Chemical stability
The product is stable at normal handling- and storage conditions.
10.3. Possibility of hazardous reactions
Will not occur.
10.4. Conditions to avoid
None.
10.5. Incompatible materials
Not determined.
10.6. Hazardous decomposition products
Other decomposition products -no data available
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Acute toxicity : LD50 Oral - rat - 3,365 mg/kg
Proprietary Component 4
LD50 oral rat
3,365 mg/kg
Skin corrosion/irritation : Causes skin irritation.
Serious eye damage/irritation : Causes serious eye irritation.
Respiratory or skin sensitisation : Not classified
Germ cell mutagenicity : Not classified
Carcinogenicity : Not classified
Reproductive toxicity : Not classified
9.2. Other information
9.1. Information on basic physical and chemical properties
04.03.14
EN (English)
5/4
Specific target organ toxicity (single exposure) : Not classified
Specific target organ toxicity (repeated
exposure)
: Not classified
Aspiration hazard : Not classified
SECTION 12: Ecological information
12.1. Toxicity
No additional inform: No data availableation available
12.2. Persistence and degradability
No additional inform: No data availableation available
12.3. Bioaccumulative potential
No additional inform: No data availableation available
12.4. Mobility in soil
No additional information available
12.5. Other adverse effects
No additional information available
SECTION 13: Disposal considerations
13.1. Waste treatment methods
Product Offer surplus and non-recyclable solutions to a licensed disposal company.
Contaminated packaging Dispose of as unused product.
Note: Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. US EPA guidelines for the
classification determination are listed in 40 CFR Parts 261.3. Additionally, waste generators must consult state and local hazardous waste
regulations to ensure complete and accurate classification.
SECTION 14: Transport information
DOT (US) Not dangerous goods
IMDG Not dangerous goods
IATA Not dangerous goods
Note:
The proper shipping name and/or hazard class for this product may vary according to packaging, properties and mode of transportation. Customer is
urged to consult 49 CFR 100-177, IMDG, IATA, EC, United Nations TDG and WHMIS (Canada) TDG information manuals for detailed regulations
and exceptions covering specific container sizes, packaging materials and methods.
SECTION 15: Regulatory information
15.1. US Federal regulations
TSCA Significant New Use Rule
None of the chemicals in this material have a SNUR under TSCA.
CERCLA Hazardous Substances and corresponding RQs
None of the chemicals in this material have an RQ.
SARA Section 302 Components
None of the chemicals in this product have a TPQ. No chemicals in this material are subject to the reporting requirements of SARA Title III, Section
302.
TSCA Section 12b
None of the chemicals are listed under TSCA Section 12b.
Proprietary C Chemical Test Rules
one of the chemicals in this product are under a Chemical Test Rule.
Health & Safety Reporting List
None of the chemicals are on the Health & Safety Reporting List.
04.03.14
EN (English)
6/4
Section 313 Components
SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (DeMinimis) reporting levels
established by SARA Title III, Section 313.
SARA 311/312 Hazards
No SARA Hazards
Clean Air Act:
This material does not contain any hazardous air pollutants. This material does not contain any Class 1 Ozone depletors. This material does not
contain any Class 2 Ozone depletors.
Clean Water Act:
None of the chemicals in this product are listed as Hazardous Substances under the CWA. None of the chemicals in this product are listed as Priority
Pollutants under the CWA. None of the chemicals in this product are listed as Toxic Pollutants under the CWA.
OSHA:
None of the chemicals in this product are considered highly hazardous by OSHA.
Risk Phrases: None allocated
Safety Phrases: S2-Keep out of reach of children, S24/25 Avoid contact with skin and eyes
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the SDS contains all of the
information required by those regulations. Canadian Ingredient Disclosure List: N/A
15.2. US State regulations
Not applicable
SECTION 16: Other information
Full text of H-phrases:
NFPA health hazard
NFPA fire hazard
: 0
: 0 - Materials that will not burn.
NFPA reactivity : 0 - Normally stable, even under fire exposure conditions,
and are not reactive with water.
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be
construed as guaranteeing any specific property of the product.
info@fast-prep.com || 802-489-0828
07/08/2013
EN (English)
Page 1
EZ Densifier
Safety Data Sheet
SECTION 1: Identification of the substance/mixture and of the company/undertaking
Product name.
:
EZ Densifier
Use of the substance/mixture
:
Concrete Densifier
EZ Polish System
PO Box 710931
Santee, CA 92072
T 844-376-5474
Emergency number
:
Chemtel 800-255-3924
SECTION 2: Hazards identification
GHS-US classification
Skin Irrit. 2
H315
Eye Irrit. 2A
H319
GHS-US labelling
Hazard pictograms (GHS-US)
:
GHS07
Signal word (GHS-US)
:
Warning
Hazard statements (GHS-US)
:
H315 - Causes skin irritation
H319 - Causes serious eye irritation
Precautionary statements (GHS-US)
:
P264 - Wash ... thoroughly after handling
P280 - Wear protective gloves/protective clothing/eye protection/face protection
P302+P352 - IF ON SKIN: Wash with plenty of soap and water
P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing
P321 - Specific treatment (see ... on this label)
P332+P313 - If skin irritation occurs: Get medical advice/attention
P337+P313 - If eye irritation persists: Get medical advice/attention
P362 - Take off contaminated clothing
No additional information available
No data available
SECTION 3: Composition/information on ingredients
Not applicable
Full text of H-phrases: see section 16
Name
Product identifier
%
GHS-US classification
Proprietary Component 1
(CAS No) Trade Secret
Trade Secret
Not classified
Proprietary Component 2
(CAS No) Trade Secret
Trade Secret
Not classified
Proprietary Component 3
(CAS No) Trade Secret
Trade Secret
Not classified
Proprietary Component 4
(CAS No) Trade Secret
Trade Secret
Acute Tox. 3 (Oral), H301
Skin Corr. 1A, H314
SECTION 4: First aid measures
First-aid measures after inhalation
:
Adverse effects not expected from this product.
2.3. Other hazards
1.1. Product identifier
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.3. Details of the supplier of the safety data sheet
1.4. Emergency telephone number
2.1. Classification of the substance or mixture
2.2. Label elements
2.4. Unknown acute toxicity (GHS US)
3.1. Substances
3.2. Mixture
4.1. Description of first aid measures
EZ Densifier
Safety Data Sheet
07/08/2013
EN (English)
2/5
First-aid measures after skin contact
:
Flush with water for at least 15 minutes. Seek medical attention if irritation develops or persists.
First-aid measures after eye contact
:
Immediately flush eyes with plenty of water for at least 15 minutes. If irritation persists get
medical attention.
First-aid measures after ingestion
:
Do NOT induce vomiting. Seek medical attention.
Symptoms/injuries after inhalation
:
None under normal use.
Symptoms/injuries after skin contact
:
Causes skin irritation.
Symptoms/injuries after eye contact
:
Causes serious eye irritation.
Symptoms/injuries after ingestion
:
May be harmful if swallowed.
No additional information available
SECTION 5: Firefighting measures
Suitable extinguishing media
:
Water spray, dry chemical, foam, carbon dioxide.
Unsuitable extinguishing media
:
None.
Fire hazard
:
None known.
Explosion hazard
:
None known.
Protection during firefighting
:
Firefighters should wear full protective gear.
SECTION 6: Accidental release measures
6.1.1.
For non-emergency personnel
No additional information available
6.1.2.
For emergency responders
No additional information available
Avoid release to the environment.
For containment
:
Stop the flow of material, if this is without risk.
Methods for cleaning up
:
Confine spill and soak up with absorbent. Place in an approved container and dispose in
accordance with local, state and federal regulations.
No additional information available
SECTION 7: Handling and storage
Precautions for safe handling
:
Avoid contact with eyes, skin and clothing. Wash thoroughly after handling.
Storage conditions
:
No special storage conditions required.
No additional information available
SECTION 8: Exposure controls/personal protection
Proprietary Component 4
USA ACGIH
ACGIH Ceiling (mg/m³)
2 mg/m³
Appropriate engineering controls
:
Provide adequate general and local exhaust ventilation.
Hand protection
:
Use impervious gloves such as neoprene, nitrile, or rubber for hand protection.
Eye protection
:
Chemical goggles or safety glasses.
Skin and body protection
:
Wear suitable working clothes.
Respiratory protection
:
If airborne concentrations are above the applicable exposure limits, use NIOSH approved
respiratory protection.
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed
5.1. Extinguishing media
5.2. Special hazards arising from the substance or mixture
5.3. Advice for firefighters
6.1. Personal precautions, protective equipment and emergency procedures
6.2. Environmental precautions
6.3. Methods and material for containment and cleaning up
6.4. Reference to other sections
7.1. Precautions for safe handling
7.2. Conditions for safe storage, including any incompatibilities
7.3. Specific end use(s)
8.1. Control parameters
8.2. Exposure controls
EZ Densifier
Safety Data Sheet
07/08/2013
EN (English)
3/5
SECTION 9: Physical and chemical properties
Physical state
:
Liquid
Colour
:
colorless.
Odour
:
odorless.
Odour threshold
:
No data available
pH
:
No data available
Relative evaporation rate (butylacetate=1)
:
No data available
Melting point
:
No data available
Freezing point
:
No data available
Boiling point
:
No data available
Flash point
:
No data available
Self ignition temperature
:
No data available
Decomposition temperature
:
No data available
Flammability (solid, gas)
:
No data available
Vapour pressure
:
No data available
Relative vapour density at 20 °C
:
No data available
Relative density
:
No data available
Solubility
:
No data available
Log Pow
:
No data available
Log Kow
:
No data available
Viscosity, kinematic
:
No data available
Viscosity, dynamic
:
No data available
Explosive properties
:
No data available
Oxidising properties
:
No data available
Explosive limits
:
No data available
No additional information available
SECTION 10: Stability and reactivity
10.1. Reactivity
No additional information available
10.2. Chemical stability
The product is stable at normal handling- and storage conditions.
10.3. Possibility of hazardous reactions
Will not occur.
10.4. Conditions to avoid
None.
10.5. Incompatible materials
Not determined.
10.6. Hazardous decomposition products
Not determined.
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Acute toxicity
:
Not classified
Proprietary Component 4
LD50 oral rat
214 mg/kg
Skin corrosion/irritation : Causes skin irritation.
Serious eye damage/irritation : Causes serious eye irritation.
Respiratory or skin sensitisation : Not classified
Germ cell mutagenicity : Not classified
Carcinogenicity : Not classified
Reproductive toxicity : Not classified
9.1. Information on basic physical and chemical properties
9.2. Other information
EZ Densifier
Safety Data Sheet
07/08/2013
EN (English)
4/5
Specific target organ toxicity (single exposure) : Not classified
Specific target organ toxicity (repeated
exposure)
: Not classified
Aspiration hazard : Not classified
SECTION 12: Ecological information
12.1. Toxicity
Proprietary Component 4
LC50 fishes 1
80 mg/l (Exposure time: 96 h - Species: Gambusia affinis [static])
12.2. Persistence and degradability
No additional information available
12.3. Bioaccumulative potential
Proprietary Component 4
Log Pow
0.65
12.4. Mobility in soil
No additional information available
12.5. Other adverse effects
No additional information available
SECTION 13: Disposal considerations
13.1. Waste treatment methods
Waste disposal recommendations
:
Dispose of contents/container in accordance with local/regional/national/international regulations.
SECTION 14: Transport information
In accordance with DOT / ADR / RID / ADNR / IMDG / ICAO / IATA
14.1. UN number
Not applicable
14.2. UN proper shipping name
Not applicable
SECTION 15: Regulatory information
15.1. US Federal regulations
Proprietary Component 2
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Proprietary Component 4
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Proprietary Component 3
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Proprietary Component 1
Listed on the United States TSCA (Toxic Substances Control Act) inventory
15.2. US State regulations
Proprietary Component 4
U.S. - Massachusetts - Right To Know List
U.S. - Minnesota - Hazardous Substance List
U.S. - New Jersey - Right to Know Hazardous Substance List
U.S. - Pennsylvania - RTK (Right to Know) List
SECTION 16: Other information
Full text of H-phrases::
Acute Tox. 3 (Oral)
Acute toxicity (oral) Category 3
Eye Irrit. 2A
Serious eye damage/eye irritation Category 2A
Skin Corr. 1A
skin corrosion/irritation Category 1A
EZ Densifier
Safety Data Sheet
07/08/2013
EN (English)
5/5
Skin Irrit. 2
skin corrosion/irritation Category 2
H301
Toxic if swallowed
H314
Causes severe skin burns and eye damage
H315
Causes skin irritation
H319
Causes serious eye irritation
NFPA health hazard : 1 - Exposure could cause irritation but only minor residual
injury even if no treatment is given.
NFPA fire hazard : 0 - Materials that will not burn.
NFPA reactivity : 0 - Normally stable, even under fire exposure conditions,
and are not reactive with water.
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be
construed as guaranteeing any specific property of the product.
info@fast-prep.com || 802-489-0828
EZ Super Guard
Page 1 of 4
EZ Super Guard
Safety Data Sheet
SECTION 1 : IDENTIFICATION
Product Nam e:
EZ Super Guard
Manufacturer Nam e: EZ Polish System
Address:
PO Box 710931
Santee, CA 92072
General Pho ne Num ber:
844-376-5474
CHEMTREC: For emergencies in the US, call CHEMTREC: 800-424-9300
SECTION 2 : HAZARD(S) IDENTIFICATION
GHS Pictogram s:
Signal Word: Warning.
GHS Class:
Eye Irritant, Category 2.
Skin Irritant, Category 2.
Hazard Statem ents: Cau ses eye an d skin irritation.
Precautionary Statem ents: Wear protective clothing, gloves, eye, an d face protection.
Do not eat, drink or smoke when using this product.
Wash hands thoroughly after handling.
Take off contaminated clothing and wash it before reuse.
Dispose of unused contents, container, and other contaminated wastes in accordance with local, state,
federal, and provincial regulations.
If in eyes
: Rinse cautiously with water for several minutes and remove contacts if present and easy to
do. Continue rinsing and get medical attention if eye irritation persists.
If on skin
: Wash with plenty of soap and water.
If swallowed
: Rinse mouth and get medical attention if you feel unwell.
Em ergency Overview:
Irritant.
Route of Exposure:
Eyes. Skin. Inhalation. Ingestion.
Potential Health Effects:
Eye:
Caus es eye irritation.
Skin:
Caus es skin irritation.
Inhalation: Prolonged or excessive inhalation m ay cause respiratory tract irritation.
Ingestion: May be harmful if swallowed. May cause vomiting.
Chronic Health Effects: Prolonged or repeated contact m ay cause skin irritation.
Signs/Symptoms: Overexposure m ay cause headach es an d dizziness.
Target Or gans: Eyes. Skin. Respiratory system. Digestive system.
Aggravation of Pre-Existing
Conditions:
None generally recognized.
SECTION 3 : COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name CA S#
Ingredient Percent
EC Num.
2,2,4-Trim ethyl-1,3- Pentanediol Monoisobutyrate
25265-77-4
1 - 5 by weight
SECTION 4 : FIRST AID MEASURES
Eye Contact: Immediately flush eyes with plenty of water for at least 15 to 20 minutes. Ensure adequate flushing of
EZ Super Guard
Page 2 of 4
the eyes by separating the eyelids with fingers. Remove contacts if present and easy to do. Continue
rinsing. Get medical attention, if irritation or symptom s of overexposure persists.
Skin Contact:
Immediately wash skin with so ap and plenty of water.
Get medical attention if irritation devel ops or persists.
Inhalation:
If inhaled, remove to fresh a ir. If not breathing, give artificial respiration or give oxygen by trained
personnel. Seek immediate medical attention.
Ingestion: If swallowed, do NO T induce vomiting. Call a physician or poison control center immediately. Never give
anything by mouth to an unconscious person.
SECTION 5 : FIRE FIGHTING MEASURES
Flash Point: None.
Lower Flam m able/Explosive Lim it: Not applicable.
Upper Flam m able/Explosive Lim it: Not applicable.
Extinguishing Media:
Use alcohol resistant foam , carbon dioxide, dry chemical, or water fog or spray when fighting fire s
involving this material.
Protective Equipment: As in any fire , wear Self-Contained Breathing Apparatus (SCBA), MSHA/NIO SH (approved or equivalent)
and full protective gear.
NFPA Ratings:
NFPA Health:
1
NFPA Flam m ability:
1
NFPA Reactivity:
0
SECTION 6 : ACCIDENTAL RELEASE MEASURES
Personal Precautions: Evacuate area and ke ep unnecessary and unprotected personnel from entering the spill area. Use
proper personal protective equipment as listed in Section 8.
Environmental Precautions: Avoid runoff into storm sewers, ditches, and waterways.
Methods for containment: Contain spills with an inert absorbent material such as soil or san d. Prevent from spreading by
covering, diking or other means . Provide ventilation.
Methods for cleanup: Clean up spills immediately observing precautions in the protective equipment section. Place into a
suitable container for disposal. Provide ventilation. After rem oval, flush spill area with soap and water
to remove trace residue.
SECTION 7 : HANDLING and STORAGE
Handling: Use with adequat e ventilation. Avoid breathing vapor an d contact with eyes, skin and clothing.
Storage: Store in a cool, dry, well ventilated area away from sources of heat, combustible materials, and
incompatible substances. Keep container tightly closed when not in use.
Hygiene Practices: Wash thoroughly after han dling. Avoid contact with eyes and skin. Avoid inhaling vapor or mist.
SECTION 8: EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls: Use appropriate en gineering control such as process enclosures, local e xha ust ventilation, or other
engineering controls to control airborne levels below recommended exposure limits. Good general
ventilation should be sufficient to control airborne levels. Where such system s are not effective wear
suitable personal protective equipment, which perform s satisfactorily and meets O SHA or other
recognized standards. Consult with local procedures for selection, training, inspection and maintenance
of the personal protective equipment.
Eye/Face Protection: Wear appropriate protective glasses or splash goggles as described by 29 CFR 1910.133, O SHA eye
and face protection regulation, or the European standard EN 166.
Skin Protection Description: Chemical-resistant gloves and chemical goggles, face-shield and synthetic apron or coveralls should be
us ed to prevent contact with eyes, skin or clothing.
Respiratory Protection: A NIO SH approved a ir-purifying respirator with an organic vapor cartridge or canister m ay be
permissible under certain circumstances where airborne concentrations are expected to exceed
exposure limits. Protection provided by a ir purifying respirators is limited. Use a positive pressure a ir
supplied respirator if there is any potential for an uncontrolled re lease, expo sure levels are not known,
or any other circumstances where a ir purifying respirators m ay not provide adequate protection.
Other Protective:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety
shower.
PPE Pictogram s:
EXPO SURE GUIDELINES
EZ Super Guard
Page 3 of 4
SECTION 9 : PHYSICAL and CHEMICAL PROPERTIES
Physical State: Liquid.
Color: opaque.
Odor: Slight.
Odor Threshold: Not applicable.
Boiling Point:
>9F (>37°C)
Melting Point:
Not applicable.
Density:
8.55
Solubility: Not applicable.
Vapor Density: Not applicable.
Vapor Pressure: Not applicable.
Evaporation Rate: Not applicable.
p H:
7 - 10
Viscosity:
50-140
Coefficient of Water/Oil
Distribution:
Not applicable.
Flam m ability: Not applicable.
Flash Point: None.
VO C Content:
98
SECTION 10 : STABILITY and REACTIVITY
Chemical Stability: Stable under norm a l temperatures and pressures.
Hazardous Polymerization: Not reported.
Conditions to Avoid:
Heat, flames, incompatible materials, and freezing or temperatures below 32 deg. F.
Incompatible Materials: Oxidizing agents. Strong acids and alkalis.
SECTION 11 : TOXICOLOGICAL INFORMATION
2,2,4-Trimethyl-1,3-Pentanediol Monoisobutyrate :
Ingestion:
Oral - Rat LD50 - Lethal dose, 50 percent k ill: 3200 m g/kg [Details of toxic effects not reported other
than lethal dos e value] (RTECS)
SECTION 12 : ECOLOGICAL INFORMATION
Ecotoxicity: No ecotoxicity data was found for the product.
Environmental Fate: No environmental information found for this product.
SECTION 13 : DISPOSAL CONSIDERATIONS
Waste Dispos al:
Consult with the US EPA Guidelines listed in 40 CFR Part 261.3 for the classifications of hazardous
waste prior to disposal. Furthermore, consult with your state and local waste requirements or guidelines,
if
applicable, to ensure compliance. Arrange disposal in accordance to the EPA and/or state and local
guidelines.
SECTION 14 : TRANSPORT INFORMATION
DO T Shipping Nam e:
Not restricted as a dan ger ous good.
DO T UN Number:
Not restricted as a dan ger ous good.
IATA Shipping Nam e:
Not restricted as a dan ger ous good.
IATA UN Number:
Not restricted as a dan ger ous good.
Canadian Shipping Nam e: Not restricted as a dangerous good.
Canadian UN Number:
Not restricted as a dan ger ous good.
IMDG UN Number:
Not restricted as a dangerous goo d.
IMDG Shipping Nam e:
Not restricted as a dangerous goo d.
ADR UN Number:
Not restricted as a dan ger ous good.
EZ Super Guard
Page 4 of 4
ADR Shipping Nam e:
Not restricted as a dan ger ous good.
SECTION 15 : REGULATORY INFORMATION
2,2,4-Trimethyl-1,3-Pentanediol Monoisobutyrate :
TSCA Inventory Status:
Listed
SECTION 16 : ADDITIONAL INFORMATION
HMIS Ratings:
HMIS Health Hazard:
1
HMIS Fire Hazard:
1
HMIS Reactivity:
0
HMIS Other:
x
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental
requirements only. It should not therefore be construed as guaranteeing any specific property of the product.